Toyota Yaris: Power Integration System / IGR Diode Stuck Off (B235A9F)

Toyota Yaris XP210 (2020-2025) Reapir and Service Manual / Power Source & Network / Power Distribution / Power Integration System / IGR Diode Stuck Off (B235A9F)

DESCRIPTION

This DTC is output when a diode failure between the IGP input and the IGR input in the power distribution box assembly is detected.

DTC No.

Detection Item

DTC Detection Condition

Trouble Area

B235A9F

IGR Diode Stuck Off

At the time of IGP input state ON, an IGR input state continues OFF state for three consecutive trips.

Power distribution box assembly

WIRING DIAGRAM

Click here

CAUTION / NOTICE / HINT

NOTICE:

  • When using the GTS with the ignition switch off to troubleshoot:

    Connect the GTS to the vehicle, and turn a courtesy switch on and off at 1.5 second intervals until communication between the GTS and vehicle begins.

  • Inspect the fuses for circuits related to this system before performing the following procedure.
  • Before performing troubleshooting, check whether there are any malfunctions with the lighting system.

    Click here

  • Before performing troubleshooting, check whether there are any malfunctions with the air conditioning system.

    Click here

  • Before performing troubleshooting, check whether there are any malfunctions with the window defogger system.

    Click here

PROCEDURE

1.

CLEAR DTC

(a) Clear the DTCs.

Body Electrical > Power Distribution Box > Clear DTCs
NEXT

2.

CHECK FOR DTC

(a) Check for DTCs.

Body Electrical > Power Distribution Box > Trouble Codes

Result

Proceed to

B235A9F is output

A

B235A9F is not output

B

A

REPLACE POWER DISTRIBUTION BOX ASSEMBLY

B

USE SIMULATION METHOD TO CHECK

    Power Distribution Box System Internal Failure (B235504)

    DESCRIPTION This DTC is output when the power distribution box assembly detects a Internal circuit error. DTC No. Detection Item DTC Detection Condition Trouble Area B235504 Power Distribution Box System Internal Failure Microcomputer abnormality AD circuit trouble The load drive output open or short trouble Power distribution box assembly WIRING DIAGRAM Click here CAUTION / NOTICE / HINT NOTICE: When using the GTS with the ignition switch off to troubleshoot: Connect the GTS to the vehicle, and turn a courtesy switch on and off at 1...

    Steering

    h..

    Other information:

    Toyota Yaris XP210 (2020-2025) Reapir and Service Manual: Disassembly


    DISASSEMBLY PROCEDURE 1. INSPECT 1ST DRIVEN GEAR THRUST CLEARANCE Click here 2. INSPECT 1ST DRIVEN GEAR RADIAL CLEARANCE Click here 3. INSPECT 2ND DRIVEN GEAR THRUST CLEARANCE Click here 4. INSPECT 2ND DRIVEN GEAR RADIAL CLEARANCE Click here 5...

    Toyota Yaris XP210 (2020-2025) Reapir and Service Manual: Removal


    REMOVAL CAUTION / NOTICE / HINT The necessary procedures (adjustment, calibration, initialization, or registration) that must be performed after parts are replaced during forward recognition camera removal/installation are shown below. Necessary Procedure After Parts Removed/Installed/Replaced Replacement Part or Performed Procedure Necessary Procedure Effect/Inoperative Function when Necessary Procedure not Performed Link Forward recognition camera Adjust forward recognition camera Dynamic Radar Cruise Control System Front Camera System Lane Tracing Assist System Pre-collision System Automatic High Beam System One Time Recognition: Sequential Recognition: Driving Adjustment: Update ECU security key Vehicle control history (RoB) are stored NOTICE: When replacing the forward recognition camera, replace it with a new one...

    Categories

    Fuel-Filler Lid and Cap

    WARNING

    When removing the fuel-filler cap, loosen the cap slightly and wait for any hissing to stop, then remove it

    Fuel spray is dangerous. Fuel can burn skin and eyes and cause illness if ingested. Fuel spray is released when there is pressure in the fuel tank and the fuel-filler cap is removed too quickly.

    read more

     
    Copyright © 2025 www.toyaris4.com